Hummer Forums by Elcova  
Forums - Home
Source Decals

Source Motors
Custom. Accessories.

H2 Accessories
H3 Accessories
Other Vehicles

H2 Source

H2 Member Photos
H2 Owners Map
H2 Classifieds
H2 Photo Gallery
SUT Photo Gallery
H2 Details

H2 Club

Chapters
Application

H3 Source

H3 Member Photos
H3 Classifieds
H3 Photo Gallery
H3 Owners Map
H3 Details
H3T Concept

H1 Source

H1 Member Photos
H1 Classifieds
H1 Photo Gallery
H1 Details

General Info

Hummer Dealers
Contact
Advertise

Sponsored Ads










 


Source Motors - custom. accessories.


Go Back   Hummer Forums by Elcova > Hummer H1 Discussion Forums > Technical Discussion and Customizing your H1

Reply
 
Thread Tools Search this Thread Display Modes
  #1  
Old 02-13-2007, 05:50 PM
brandash10 brandash10 is offline
Hummer Novice
 
Join Date: Feb 2007
Location: Provo, Utah
Posts: 10
brandash10 is on a distinguished road
Default Newbie Question: 2000H1 keeps stalling

I just bought a 2000 H1 with 12,800 miles and it has been running great until the last few days. The vehicle has stalled/ quit running on me three times in the last week or so. I have had no previous problems with it and don't know what could be causing it to stall or to shut off while I am driving. Anyone with ideas or help?
Reply With Quote
  #2  
Old 02-13-2007, 05:55 PM
Ground hawg's Avatar
Ground hawg Ground hawg is offline
Hummer Veteran
 
Join Date: Jan 2006
Location: Bellefontaine Ohio
Posts: 203
Ground hawg is an unknown quantity at this point
Default Re: Newbie Question: 2000H1 keeps stalling

you got any more info? does it start right back up. is it -30 out side. anything else happening when this happens??
Reply With Quote
  #3  
Old 02-13-2007, 06:10 PM
DRTYFN's Avatar
DRTYFN DRTYFN is offline
Hummer Messiah
 
Join Date: Nov 2002
Location: PDX
Posts: 2,367,817
DRTYFN is an unknown quantity at this point
Default Re: Newbie Question: 2000H1 keeps stalling

Bad fuel, fuel filter plugged... Without more info you won't get much more than off the wall guesses.
Reply With Quote
  #4  
Old 02-13-2007, 07:52 PM
brandash10 brandash10 is offline
Hummer Novice
 
Join Date: Feb 2007
Location: Provo, Utah
Posts: 10
brandash10 is on a distinguished road
Default Re: Newbie Question: 2000H1 keeps stalling

The weather here is actually pretty warm lately. It has been around 20 degrees Farenheit during the night and 40 degrees during the day. The vehicle started back up with no problems and no engine light came on or anything. The vehicle stalled while I was pulling out of a parking lot and then started back up and stalled again when I was pulling forward and started back up after two tries. I got on the road and the vehicle turned off while I was driving, so I pulled over and it started back up. The engine sounds good and I am not hearing any unfamiliar noises. On one other occasion the vehicle turned off when I went over a big bump, I don't know if that was a cause of anything in particular. That is all the information I have.
Reply With Quote
  #5  
Old 02-14-2007, 01:15 AM
brandash10 brandash10 is offline
Hummer Novice
 
Join Date: Feb 2007
Location: Provo, Utah
Posts: 10
brandash10 is on a distinguished road
Default Re: Newbie Question: 2000H1 keeps stalling

Quote:
Originally Posted by Ground hawg
you got any more info? does it start right back up. is it -30 out side. anything else happening when this happens??
The weather here is actually pretty warm lately. It has been around 20 degrees Farenheit during the night and 40 degrees during the day. The vehicle started back up with no problems and no engine light came on or anything. The vehicle stalled while I was pulling out of a parking lot and then started back up and stalled again when I was pulling forward and started back up after two tries. I got on the road and the vehicle turned off while I was driving, so I pulled over and it started back up. The engine sounds good and I am not hearing any unfamiliar noises. On one other occasion the vehicle turned off when I went over a big bump, I don't know if that was a cause of anything in particular. That is all the information I have.
Reply With Quote
  #6  
Old 02-14-2007, 01:32 AM
ssgharkness020147's Avatar
ssgharkness020147 ssgharkness020147 is offline
Hummer Authority
 
Join Date: Jan 2004
Location: WI
Posts: 1,812
ssgharkness020147 is an unknown quantity at this point
Default Re: Newbie Question: 2000H1 keeps stalling

Start by changing out the fuel filter, you may have gotten bad diesel. I'm probably going to bank on your PMD being shot, its the driver that controls the injector pump and is a VERY common failure on the H1. I wrote an article on it and how to change it out/mount it remotely a few years back. http://flashoffroad.com/Diesel/injectionpump/fsd.htm

http://flashoffroad.com/Diesel/injec...FSDInstall.htm

Take the truck in and have the codes pulled. If there are not codes and the stalling persists you can bet it the PMD. Very rarely will a PMD failure give any codes. If it is in fact bad make sure to mount it remotely, this will reduce the chances of it failing down the road. And if it does replacing it is a 15 minute job, putting it back on the injector pump is BIG $$$ and only ensures that you will have to replace it again, mounting it on the pump was a design flaw.
__________________
1997.5 Black Slantback
The Sole Remaining God Father

-007=
Reply With Quote
  #7  
Old 02-16-2007, 03:45 AM
smitham smitham is offline
Hummer Veteran
 
Join Date: Dec 2005
Location: Orlando FL
Posts: 27
smitham is off the scale
Default Re: Newbie Question: 2000H1 keeps stalling

I would second the PMD. I just got my truck out of the shop the other day and for the same thing. My truck would stall on me for no reason going down the road and then start right back up again.

I took my truck to a diesel truck shop. they were actualy the state rep for the manufacture of our injector pumps. They were able to provide a lot better service than I think the dealer would have and were cheaper.
__________________
1997.5 4 door Hardtop for me
2006 H3 Advenure Pkg for her
Reply With Quote
  #8  
Old 03-09-2007, 12:30 AM
J.T.'s Avatar
J.T. J.T. is offline
Hummer Veteran
 
Join Date: May 2006
Location: Yuba City, Northern California
Posts: 56
J.T. is off the scale
Default Re: Newbie Question: 2000H1 keeps stalling

Quote:
Originally Posted by smitham
I would second the PMD. I just got my truck out of the shop the other day and for the same thing. My truck would stall on me for no reason going down the road and then start right back up again.

I took my truck to a diesel truck shop. they were actualy the state rep for the manufacture of our injector pumps. They were able to provide a lot better service than I think the dealer would have and were cheaper.

I'd bet on this being it as well same thing happened with my 03" dealer replaced and relocated it under warranty......fine now (fingers crossed)
__________________
J.T.
2003 H1 Open Top 6.5 w/ 22"x12" Weld Cheyenne 8s with 37" Toyo Open Country Tires
Reply With Quote
  #9  
Old 05-28-2007, 03:00 AM
Carbine Carbine is offline
Hummer Novice
 
Join Date: May 2007
Posts: 14
Carbine is on a distinguished road
Default Re: Newbie Question: 2000H1 keeps stalling

STOP! Check for back pressure at the fuel tank vent valve! Injectors have to cool and return fuel goes back to the fuel tank so make sure you clean it if you have one. #2 the fuel injector pump should have a governor ring that might be bad. Fuel shut off solenoid because of the heat might be getting stubborn so throw cold water on the top of the Injector pump the next time it stalls, if it does I would want to blame the fuel shutoff solenoid.
Reply With Quote
Reply


Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

vB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Forum Jump


All times are GMT +1. The time now is 10:06 AM.


Powered by vBulletin Version 3.0.7
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.